Santa Cruz AWD

59 service bulletins filed with NHTSA for this model year

• Jun 5, 2026POWER TRAIN26-AT-005H TSB

  This bulletin provides information related to a Transmission Control Unit (TCU) software update for some vehicles equipped with an 8-speed wet dual clutch transmission (8WDCT). The software update revises the touch point learning variation, improving drivability and judder symptoms. Some 8WDCTs (indicated by a new part number) received an updated clutch spring. The correct TCU software update must be matched with the correct corresponding 8WDCT hardware, otherwise, drivability concerns may occur

• Apr 10, 2026AIR BAGSDTN DL

  The National Highway Traffic Safety Administration (NHTSA) has identified the presence of substandard and dangerous driver’s-side airbag inflators manufactured by Jilin Province Detiannuo Automobile Safety System Co., Ltd. (DTN). These inflators were not supplied, approved, or authorized by the vehicle manufacturers and have primarily been found in vehicles that previously experienced a crash and underwent airbag replacement using non-genuine parts. These dangerous inflators have ruptured during

• Apr 10, 2026AIR BAGSDTN DCS

  The National Highway Traffic Safety Administration (NHTSA) has issued an urgent safety advisory regarding dangerous, counterfeit driver‑side airbag inflators manufactured by Jilin Province Detiannuo Automobile Safety System Co., Ltd. (DTN), that have been identified in U.S. vehicles following prior crashes, theft, or non‑certified airbag replacements. These inflators are not approved for use, may rupture during deployment, and have caused serious injuries and fatalities. Please see attached anno

• Mar 16, 2026POWER TRAIN26-01-028H

  Certain Santa Cruz (NXT) vehicles equipped with 8-speed dual clutch transmissions (8DCT) may set one of the high pressure electric oil pump (HP EOP) DTCs listed below. This bulletin provides the service procedure to update the Transmission Control Unit (TCU) with improved logic to address these DTCs and enhance operation of the 8DCT.

• Mar 3, 2026POWER TRAIN26-AT-001H TSB

  Some Santa Cruz (NXT), Santa Fe (TMA, MX5A), and Sonata (DN8A) models may require replacement of the 8-speed wet dual clutch transmission (8WDCT) when the vehicle sets one of the high pressure electric oil pump (HP EOP) DTCs listed below. This bulletin provides instructions to replace the 8WDCT.

• Feb 25, 2026FORWARD COLLISION AVOIDANCE: WARNINGS26-AD-001H TSB

  Some 2019MY and newer vehicles equipped with a front view camera may illuminate certain warning lights and trigger DTC C272246 fault code for the front camera. In the following cases, the front camera auto-calibration range may be exceeded while driving: • If the front camera is not properly installed and is completely or partially detached. • In case of excessive changes affecting the vehicle's balance (e.g., loading excessively heavy cargo in a specific location of the vehicle, or significant

• Jan 24, 2026STRUCTURE:BODY25-BD-011H-1 TSB

  Some Santa Cruz (NXT) vehicles may have a tonneau cover that does not latch or unlatch, retract properly, and/or have a v-gap is present when closed. This may be due to a broken or missing clip on the underside of the tonneau cover. This bulletin provides instructions to inspect and, if necessary, repair the tonneau cover function using the Tonneau Cover Repair Kit or replacing the tonneau handle & latch assembly.

• Jan 7, 2026FUEL/PROPULSION SYSTEM26-FL-001H TSB

  Some vehicles equipped with a 2.5L GDI Theta III engine (non-Turbo) may exhibit one or more misfire DTCs due to the GDI fuel injectors leaking internally. This may be caused by internal filter breakage in the injector. Follow the procedure in this TSB to replace all 4 injectors on affected vehicles, using the kit in the Parts Information section.

• and 51 more

Source: NHTSA manufacturer communications (technical service bulletins).