Corsair AWD PHEV

142 service bulletins filed with NHTSA for this model year

• May 18, 2026UNKNOWN OR OTHERTSB 26-2205

  This bulletin supersedes 25-2346. Reason for update: add Bronco Sport and Escape vehicles and add labor operations to repair the rear right/left carpet area. Some of the vehicles listed in the Model statement above may exhibit a condition where the carpet is loose or torn near the front/rear scuff plate trim panel. This may be due to the carpet tearing at or near the retainer hole.

• May 4, 2026POWER TRAINSSM 54797

  Some 2020-2026 Corsair/Escape, 2021-2026 Bronco Sport, and 2022-2026 Maverick vehicles equipped with an 8F35 transmission may exhibit a shudder condition, most noticeable at speeds below 60 mph (100 km/h), with no relevant diagnostic trouble codes (DTC) stored in the powertrain control module (PCM). Sometimes, this may be perceived/felt as an engine misfire. This may be due to the torque converter. If Pinpoint Test K: Torque Converter Clutch Operation in Workshop Manual (WSM), Section 307-01 > D

• Apr 29, 2026EXTERIOR LIGHTINGTSB 26-2198

  This article supersedes TSB 23-2395 Reason for update: update the affected vehicle model years, add a production cut off date, and include a parts list with the Rotunda part number of the flock tape. Some of the vehicles listed in the Model statement above may exhibit a squeak or rattle noise from the center display screen. This may be due to improperly installed or missing center display screen grommets, causing contact between the center display screen and the instrument panel ambient light ba

• Apr 26, 2026POWER TRAINTSB 26-2194

  This bulletin supersedes 25-2627. Reason for update: To add a Step to reprogram the all-wheel drive (AWD) module for Bronco Sport vehicles. Some of the vehicles listed in the Model statement above may exhibit all of the following conditions:  Shudder chatter condition, most noticeable at low speeds turning  No relevant diagnostic trouble codes (DTCs) present This may be due to internal rear drive unit (RDU) fluid contamination.

• Apr 8, 2026ELECTRICAL SYSTEMSYNC-25.1.7.10.1 Corsair

  25S49 Recall Remedy: -Infotainment software update to address frozen screens

• Apr 8, 2026ELECTRICAL SYSTEM23B64

  Customer Satisfaction Program 23B64 Certain 2020-2024 Model Year Multiple Vehicle Lines Equipped with High Voltage Batteries Battery Energy Control Module (BECM) Software Update

• Apr 2, 2026LANE DEPARTURE: BLIND SPOT DETECTIONSSM 54720

  Various 2020-2026 Ford and Lincoln vehicles equipped with blind spot information system (BLIS) may experience an inoperative blind spot monitoring with a "Blind Spot System Fault" message displayed in the instrument panel cluster (IPC). This may also be accompanied by diagnostic trouble codes (DTCs) B118C:11 and/or B118C:15 stored in the driver door module (DDM), and/or B118D:11 and/or B118D:15 stored in the passenger door module (PDM). This may be due to the wiring connector from the mirror to

• Mar 20, 2026ELECTRICAL SYSTEM24L10 S1

  Certain 2021-2025 Model Year Corsair Vehicles- Flat Tow Rating Change On the affected vehicles, documentation in the owner’s manual incorrectly states that 2021 – 2025 Corsair PHEV (Plug-in Hybrid Electric Vehicles) can be recreationally flat towed. You cannot recreationally flat tow these vehicles with all wheels on the ground because damage to the powertrain may occur. All 2023-2025 model year vehicles will require dealers to perform a software update to the Accessory Protocol Interface Module

• and 134 more

Source: NHTSA manufacturer communications (technical service bulletins).